發布時間：2018-09-09 10:38

【摘要】：為了研究電纜水樹修復的長期效果,對修復和未修復的水樹老化電纜樣本進行了電熱協同老化,對比分析了2組電纜樣本的電氣性能和微觀結構變化。利用加速水樹老化實驗平臺,采用水針電極老化法在交聯聚乙烯(XLPE)電纜樣本中生成了水樹缺陷,對其中1組樣本進行了注入式修復,對另1組樣本則不做處理,之后利用電熱協同老化實驗平臺對2組樣本同時進行了電熱老化。對電熱老化前后樣本的顯微鏡觀測結果表明,電熱老化2周時間后,修復樣本的水樹整體尺寸明顯小于未修復樣本;介質損耗因數的測試結果表明,電熱老化2周時間后,修復樣本的絕緣性能遠高于未修復樣本;對2組樣本水樹老化區域的掃描電鏡(SEM)觀測和能譜儀(EDS)分析結果表明,修復樣本在電熱老化2周時間后,水樹空洞內部仍有修復生成的填充物與XLPE基體緊密結合。基于以上發現,證明了在電熱老化過程中,水樹空洞內的修復填充物能夠有效抑制已有水樹的繼續生長并保持長期作用。
[Abstract]:In order to study the long-term effect of cable water tree restoration, the electrothermal co-aging of repaired and unrepaired water tree aged cable samples was carried out. The electrical properties and microstructure changes of two groups of cable samples were compared and analyzed. Using the accelerated water tree aging test platform, the water tree defect was generated in the (XLPE) cable sample by the method of water needle electrode aging. One group of samples was repaired by injection, and the other group was not treated. After that, two groups of samples were subjected to electrothermal aging simultaneously using the electrothermal co-aging experimental platform. The microscopic observation results of samples before and after electrothermal aging showed that after electrothermal aging for 2 weeks, the whole size of water tree of repaired samples was obviously smaller than that of unrepaired samples, and the dielectric loss factor test showed that after 2 weeks of electrothermal aging, the whole size of water tree of repaired samples was obviously smaller than that of unrepaired samples. The insulation properties of the repaired samples were much higher than those of the unrepaired samples, and the results of scanning electron microscope (SEM) (SEM) observation and (EDS) analysis of the water tree aging area of the two groups of samples showed that the repaired samples were aged for 2 weeks after electrothermal aging. The inner cavity of the water tree is still filled with repaired fillers which are closely bound to the XLPE matrix. Based on the above findings, it is proved that in the process of electrothermal aging, the repair filler in the water tree cavity can effectively inhibit the continued growth of the existing water tree and maintain the long-term effect.
【作者單位】： 四川大學電氣信息學院;云南電網有限責任公司電力調度控制中心;
【基金】：國家自然科學基金(51477106)~~
【分類號】：TM247

【相似文獻】

相關期刊論文 前10條

1 豆朋,文習山,龔瑛;幾種因素對水樹生長影響的研究[J];絕緣材料;2005年01期

2 亢婕,黨智敏,屠德民;抑制聚乙烯中水樹生長的試驗研究[J];絕緣材料;2001年02期

3 黨智敏,亢婕,屠德民;聚烯烴中水樹和吸水規律的研究[J];電線電纜;2001年03期

4 金天雄;黃興溢;江平開;劉飛;鄭學哲;;用有限元法分析水樹尺寸對電場分布的影響[J];高電壓技術;2008年03期

5 周凱;趙威;管順剛;袁林;陶文彪;;硅氧烷對水樹老化后的交聯聚乙烯電纜的修復研究[J];電工技術學報;2013年01期

6 金天雄;黃興溢;馬芝森;江平開;玄勝日;;γ輻照交聯聚乙烯絕緣電纜水樹行為的研究[J];絕緣材料;2008年06期

7 吳炯;吳也強;王瑞禹;王惠明;;交聯聚乙烯電纜直流水樹的試驗研究[J];電工技術學報;1988年02期

8 汪朝軍;田鵬;劉勇;周凱;吳超;趙威;;有機硅注入技術對電纜水樹缺陷的絕緣修復研究[J];絕緣材料;2011年06期

9 黨智敏,亢婕,屠德民,阮建國,陳剛;乙烯-丙烯酸共聚物用作交聯聚乙烯絕緣水樹抑制劑的研究[J];電線電纜;2001年01期

10 豆朋,文習山;交聯聚乙烯電纜中水樹研究的現狀[J];絕緣材料;2005年02期

相關碩士學位論文 前2條

1 周秀;電力電纜水樹在線檢測新方法的研究[D];長沙理工大學;2011年

2 黃曉峰;交聯聚乙烯電力電纜絕緣老化評估及修復方法研究[D];西南交通大學;2014年

，

本文編號：2232141