水包水型疏水締合聚丙烯酰胺增稠劑的合成及在壓裂中的應用
發布時間：2018-10-25 19:15
【摘要】：以丙烯酰胺、2-丙烯酰胺-2-甲基丙磺酸和芥酸酰胺羥丙基磺基甜菜堿為原料,采用水分散聚合方式合成出水包水型疏水締合聚丙烯酰胺增稠劑,通過FTIR和TG對增稠劑的結構及熱解質量進行了測試。分析了OWPAM乳液增稠劑的基本性能及水溶液的微觀和宏觀性能,結果表明,在單體芥酸CAB用量為4.0%時,乳液的產率、平均粒徑、表觀黏度和穩定性達到最優,黏均分子量為2.43×10~6g/mol;OWPAM乳液的臨界膠束締合濃度(CAC)值為0.32%,當濃度大于CAC值后水溶液體系內的締合形式以分子間締合為主,OWPAM乳液在0.1%、流速10m/s時減阻率為72%。助黏劑TR-1質量分數為1.0%時可將0.5%水溶液黏度增加至160mPa·s,復配成的壓裂液具有較好耐溫耐剪切性、黏彈性和懸砂性,在APS質量分數為0.05%時,測試時間為2h壓裂液可以完全破膠,能夠達到壓裂液的使用標準。
[Abstract]:Hydrophobically associating polyacrylamide thickener was synthesized from acrylamide, 2-acrylamide 2-methylpropanesulfonic acid and erucide-aminohydroxypropyl sulfobetaine by water dispersion polymerization. The structure and pyrolysis quality of thickener were tested by FTIR and TG. The basic properties of OWPAM emulsion thickener and the microcosmic and macroscopic properties of aqueous solution were analyzed. The results showed that the emulsion yield, average particle size, apparent viscosity and stability were optimal when the amount of erucic acid CAB was 4.0. The viscosity average molecular weight is 2.43 脳 10 ~ (-1) g / mol; The critical micelle association concentration (CAC) of OWPAM emulsion is 0.32. When the concentration is higher than CAC value, the main form of association in aqueous solution is intermolecular association. The OWPAM emulsion is 0.1 and the drag reduction rate is 72 when the flow rate of 10m/s is 10m/s. The viscosity of 0.5% aqueous solution can be increased to 160mPa s when the mass fraction of TR-1 is 1.0. The composite fracturing fluid has good temperature and shear resistance, viscoelasticity and suspending sand. When the mass fraction of APS is 0.05, The test time is 2 h, the fracturing fluid can break completely, and it can reach the standard of fracturing fluid.
【作者單位】： 教育部輕化工助劑化學與技術重點實驗室陜西科技大學;陜西延長石油(集團)有限責任公司研究院;
【基金】：國家科技重大專項項目(2017ZX05039004、ycsy2017QNJJB-08)
【分類號】：TE39
[Abstract]:Hydrophobically associating polyacrylamide thickener was synthesized from acrylamide, 2-acrylamide 2-methylpropanesulfonic acid and erucide-aminohydroxypropyl sulfobetaine by water dispersion polymerization. The structure and pyrolysis quality of thickener were tested by FTIR and TG. The basic properties of OWPAM emulsion thickener and the microcosmic and macroscopic properties of aqueous solution were analyzed. The results showed that the emulsion yield, average particle size, apparent viscosity and stability were optimal when the amount of erucic acid CAB was 4.0. The viscosity average molecular weight is 2.43 脳 10 ~ (-1) g / mol; The critical micelle association concentration (CAC) of OWPAM emulsion is 0.32. When the concentration is higher than CAC value, the main form of association in aqueous solution is intermolecular association. The OWPAM emulsion is 0.1 and the drag reduction rate is 72 when the flow rate of 10m/s is 10m/s. The viscosity of 0.5% aqueous solution can be increased to 160mPa s when the mass fraction of TR-1 is 1.0. The composite fracturing fluid has good temperature and shear resistance, viscoelasticity and suspending sand. When the mass fraction of APS is 0.05, The test time is 2 h, the fracturing fluid can break completely, and it can reach the standard of fracturing fluid.
【作者單位】： 教育部輕化工助劑化學與技術重點實驗室陜西科技大學;陜西延長石油(集團)有限責任公司研究院;
【基金】：國家科技重大專項項目(2017ZX05039004、ycsy2017QNJJB-08)
【分類號】：TE39
【參考文獻】
相關期刊論文 前10條
1 張鋒三;沈一丁;王磊;馬國艷;蘇瑩;任婷;;聚丙烯酰胺壓裂液減阻劑的合成及性能[J];化工進展;2016年11期
2 鄒才能;董大忠;王玉滿;李新景;黃金亮;王淑芳;管全中;張晨晨;王紅巖;劉洪林;拜文華;梁峰;吝文;趙群;劉德勛;楊智;梁萍萍;孫莎莎;邱振;;中國頁巖氣特征、挑戰及前景(一)[J];石油勘探與開發;2015年06期
3 王明磊;張遂安;關輝;劉玉婷;管保山;張福東;崔偉香;;致密油儲層特點與壓裂液傷害的關系——以鄂爾多斯盆地三疊系延長組長7段為例[J];石油與天然氣地質;2015年05期
4 邱振;李建忠;吳曉智;王社教;鄭民;郭秋麟;;國內外致密油勘探現狀、主要地質特征及差異[J];巖性油氣藏;2015年04期
5 曹U，
本文編號：2294582
本文鏈接：http://www.wukwdryxk.cn/kejilunwen/shiyounenyuanlunwen/2294582.html
教材專著
