發布時間：2018-10-17 08:50

【摘要】：瞬時轉速信號中包含著豐富的能夠反映柴油機氣缸做功能力的信息。所以基于瞬時轉速的柴油機故障診斷技術在國內外都進行了大量的研究，而其測量方便且簡單實用的優點使得該技術在診斷柴油機氣缸運行狀態的應用上得到了極高的重視。但是目前對于瞬時轉速的應用多集中在點火間隔角較大的直列柴油機，對于點火間隔角較小的16缸V型柴油機應用效果較差。這是因為反映在瞬時轉速信號上的每個特征都可能是多個氣缸耦合的作用，這就為故障的定位和識別增加了難度。而本文以此為出發點，對瞬時轉速在16缸V型柴油機上的應用就行探索性研究。 首先，本文研究了瞬時轉速的測量方法，，構建了瞬時轉速測量系統。通過分析實測飛輪端原始信號的特點，采用數字濾波的方法對信號進行預處理。并應用零點法和解調法兩種計算原理完全不同的方法來相互輔證瞬時轉速波形計算的準確性。 其次，利用上文求得的瞬時轉速波形，提取幾種目前常用的特征參數，對柴油機氣缸運行狀態進行評價，對比分析評價結果簡述其在16缸V型柴油機上應用效果不好的原因，并基于以上分析提出能夠更好地反映氣缸運行狀態的特征參數：瞬時轉速峰值、谷值的趨勢變化以及經去均值處理的瞬時角速度與瞬時角加速度，同時指出這些特征參數的應用條件。 最后，在能夠準確定位故障缸的前提下應用統計分析的方法確定能夠更為精確表征故障嚴重程度的特征參數，并結合以上分析建立診斷模型，通過實測數據驗證模型的準確性
[Abstract]:The instantaneous speed signal contains abundant information which can reflect the work ability of diesel engine cylinder. Therefore, diesel engine fault diagnosis technology based on instantaneous speed has been studied extensively at home and abroad, and its advantages of convenient and practical measurement make the application of this technology in the diagnosis of diesel engine cylinder running state to be highly valued. But at present, most of the applications of instantaneous speed are focused on the in-line diesel engine with larger ignition interval angle, but the application effect is poor for 16-cylinder V-type diesel engine with small ignition interval angle. This is because each feature reflected in the instantaneous speed signal may be coupled with multiple cylinders, which makes it more difficult to locate and identify faults. In this paper, the application of instantaneous speed in 16 cylinder V diesel engine is studied. Firstly, the measurement method of instantaneous speed is studied, and the system of measuring instantaneous speed is constructed. By analyzing the characteristics of the original signal at the end of the flywheel, the digital filter is used to preprocess the signal. The zero point method and demodulation method are used to verify the accuracy of instantaneous speed waveform calculation. Secondly, by using the instantaneous speed waveform obtained above, several commonly used characteristic parameters are extracted to evaluate the operating state of diesel engine cylinder. The results of comparative analysis and evaluation describe the reasons for its poor application in 16-cylinder V-type diesel engine. Based on the above analysis, the characteristic parameters which can better reflect the running state of the cylinder are proposed, such as the peak speed of instantaneous speed, the trend change of valley value, and the instantaneous angular velocity and angular acceleration treated by de-mean value. At the same time, the application conditions of these characteristic parameters are pointed out. Finally, under the premise of locating the fault cylinder accurately, the statistical analysis method is applied to determine the characteristic parameters which can more accurately characterize the severity of the fault. Combined with the above analysis, the diagnostic model is established, and the accuracy of the model is verified by the measured data.
【學位授予單位】：哈爾濱工業大學
【學位級別】：碩士
【學位授予年份】：2014
【分類號】：U664.121;U672.74

【參考文獻】

相關期刊論文 前10條

1 王明鶴;徐金良;季晨龍;;基于頻率解調方法的柴油機瞬時轉速信號計算[J];柴油機;2012年02期

2 白廣來,孟憲堯;發動機瞬態轉速與氣壓扭矩波形的研究[J];大連海事大學學報;2000年03期

3 周加?xùn)|;歐陽光耀;歐大生;程付安;;基于頻率解調方法的柴油機瞬時轉速信號計算[J];內燃機;2010年03期

4 劉世元,杜潤生,楊叔子;利用轉速波動信號診斷內燃機失火故障的研究(2)——波形分析方法[J];內燃機學報;2000年03期

5 劉世元,杜潤生,楊叔子;利用轉速波動信號診斷內燃機失火故障的研究(3)——多特征綜合方法[J];內燃機學報;2000年04期

6 胡玉平,吳波;內燃機瞬時轉速的波動規律分析[J];山東工業大學學報;2001年04期

7 閆兵,董大偉,華春蓉,秦萍;利用曲軸扭振相位特性診斷機車柴油機氣缸氣密性的新方法[J];鐵道學報;2003年05期

8 蔡艷平;李艾華;胡重慶;郭明芳;;平穩小波自適應去噪用于曲軸瞬時角加速度測量[J];振動.測試與診斷;2010年03期

9 楊建國,王曉武;船舶柴油機監測與故障診斷技術現狀及發展趨勢[J];中國航海;1999年02期

10 馬晉;江志農;高金吉;;基于瞬時轉速波動率的內燃機故障診斷方法研究[J];振動與沖擊;2012年13期

相關博士學位論文 前1條

1 唐娟;基于振動信號評價柴油機缸內燃燒狀態的研究[D];山東大學;2010年

本文編號：2276144