絕緣子表面雨凇覆冰粘結力及其影響因素研究
發布時間：2018-07-24 14:09
【摘要】：雨凇覆冰對電力系統安全運行造成了嚴重影響,國內外針對覆冰粘結力進行了大量研究,但大多數采用的是金屬和玻璃材質,尚未深入分析雨凇覆冰狀態下絕緣子材質的覆冰粘結力�；诙喙δ苋斯夂蚴�,以瓷、玻璃、復合硅橡膠為基底模擬絕緣子表面材質,從冰層溫度、防冰涂料、材料憎水性、覆冰水電導率等幾個方面對雨凇覆冰粘結力進行了試驗研究。研究結果表明:不同材料的雨凇覆冰粘結力不同,復合硅橡膠板的粘結力低于瓷板和玻璃板;雨凇覆冰粘結力隨冰層溫度的降低先升高后降低,在溫度為-8℃時達到最高;涂覆憎水性涂料后,瓷板和玻璃板的雨凇覆冰粘結力顯著下降,且高自潔防污閃涂料的防冰性能優于持久性就地成型防污閃復合涂料;雨凇覆冰粘結力隨著材料表面的憎水性升高而降低;覆冰水電導率對雨凇覆冰粘結力的影響較小。研究結果可為雨凇頻發地區的絕緣子防冰工作提供參考。
[Abstract]:Rime icing has a serious impact on the safe operation of power system. A great deal of research has been done at home and abroad on the adhesion of icing, but most of them are made of metal and glass. The adhesion of insulator material under the condition of rime and ice has not been deeply analyzed. Based on the multifunctional artificial climate chamber, using porcelain, glass, composite silicone rubber as the substrate to simulate the insulator surface material, from the ice layer temperature, the ice-proof coating, the material hydrophobicity, The adhesive force of rime covered with ice was studied in several aspects, such as the conductivity of icing water. The results show that the adhesive force of the composite silicone rubber plate is lower than that of the porcelain plate and glass plate, and the adhesion strength of the composite silicone rubber plate increases first and then decreases with the decrease of the ice temperature, and reaches the highest at -8 鈩，
本文編號：2141618
[Abstract]:Rime icing has a serious impact on the safe operation of power system. A great deal of research has been done at home and abroad on the adhesion of icing, but most of them are made of metal and glass. The adhesion of insulator material under the condition of rime and ice has not been deeply analyzed. Based on the multifunctional artificial climate chamber, using porcelain, glass, composite silicone rubber as the substrate to simulate the insulator surface material, from the ice layer temperature, the ice-proof coating, the material hydrophobicity, The adhesive force of rime covered with ice was studied in several aspects, such as the conductivity of icing water. The results show that the adhesive force of the composite silicone rubber plate is lower than that of the porcelain plate and glass plate, and the adhesion strength of the composite silicone rubber plate increases first and then decreases with the decrease of the ice temperature, and reaches the highest at -8 鈩，
本文編號：2141618
本文鏈接：http://www.wukwdryxk.cn/kejilunwen/dianlilw/2141618.html
