發布時間：2019-03-31 16:39

【摘要】：針對丙烷和液體石蠟選擇性氧化制備脂肪酸的催化劑篩選與制備關鍵技術問題,本文以草酸鈮、碲酸、鉬酸銨、偏釩酸銨、硝酸鎳和ZSM-5為原料制備了多金屬氧化物基催化劑MoVTeNbO、Mo VTe Nb Ni O,V2O5/ZSM-5系列催化劑,分別用于催化丙烷氧化轉化制取丙烯酸和催化液體石蠟氧化轉化制取脂肪酸。用SEM、EDX、XRD、XPS、Raman、H2-TPR、NH3-TPD和FT-IR對催化劑進行了表征和功能特性研究,研究結果表明:(1)制備MoVTeNbO催化劑制備的最佳條件為:漿液法,元素比Mo:V:Nb:Te=1:0.3:0.12:0.23,焙燒溫度600℃,惰性氣氛下制取的催化劑具有高含量的活性相和最佳的丙烯酸產率。MoVTeNbO氧化轉化丙烷的最佳條件:40目催化劑為0.4g,通入的混合反應氣烷氧比為2:3,反應溫度為400℃時丙烯酸產率最高,達到了16.1%,其中丙烷轉化率為50.1%,丙烯酸選擇性為33.2%。(2)對MoVTeNbO的改性研究發現Te元素在MoVTeNbO催化氧化丙烷過程中主要起丙烯酸的選擇作用;Mo1V0.3Te0.23Nb0.12Ni0.008O對丙烷氧化轉化丙烯酸的性能優于其它Ni含量摻雜的催化劑,丙烯酸產率為17.9%。其中丙烷轉化率為51.9%,丙烯酸選擇性為34.5%。(3)MoVNbO在液體石蠟的氧化轉化過程中只起催化作用,V元素為MoVNbO的主要催化元素。ZMS-5為載體,采用共沉淀法制備V2O5/ZSM-5催化劑可用于液體石蠟催化氧化轉化脂肪酸。當反應溫度為150℃,反應時間為8 h,催化劑用量為0.1g時,在純氧氣氛下氧化產物酸值為17.33mg(KOH)/g、皂化值為33.52mg(KOH)/g。
[Abstract]:In this paper, niobium oxalate, tellurate, ammonium molybdate and metavanadate were selected as catalysts for selective oxidation of propane and liquid paraffin to prepare fatty acids. Polymetallic oxide-based catalysts MoVTeNbO,Mo VTeNb Ni-O and V _ 2O _ 5 / ZSM _ 5 series catalysts were prepared from nickel nitrate and ZSM-5. The catalysts were used for catalytic conversion of propane to acrylic acid and oxidation conversion of liquid paraffin to fatty acids, respectively. The catalysts were characterized and characterized by SEM,EDX,XRD,XPS,Raman,H2-TPR,NH3-TPD and FT-IR. The results showed that: (1) the optimum conditions for preparing MoVTeNbO catalysts were: slurry method; The calcination temperature of the element is 600 鈩，

本文編號：2451085